修补环氧地坪的方法，各有优缺点，具体要还需要运用不同的方法来进行不同的破损补修。方法各有优劣，重点在于合理的选择不同的方法进行不同破损的修 补。无锡环氧地坪修补工作是繁琐的，为了减少修补的机率，我们在施工时就应该严谨的施工，客户在使用时也应该按照正确方式使用。把环氧地坪漆材料运输中到工地时要注意，如果是大批量采用专用的集装箱或包装箱，防止任何火种的混入，并保持温度不能过高15～25℃，不得与其他化学药品等货物混装。到达目的地时，不可直接外在露天地方，应用篷布覆盖，不得日晒雨淋，包装一旦破损，要及时更换包装，但禁止现场焊补。环氧地坪材料不管是在厂家的仓库，还是运到施工现场都要妥善保管，不可以把材料放在阳光下爆晒，避免放置离火种近或者有火种的地方。因为环氧材料属于易燃易爆物品，在保存和放置点一定要严格遵守材料的储存条件，预防因各种问题引起火灾和爆炸事故。

The methods of repairing epoxy floor have their own advantages and disadvantages, and different methods should be used to repair different damages. Each method has its own merits and demerits. The key point is to choose different methods to repair different damages reasonably. Repair of epoxy floor is tedious. In order to reduce the probability of repair, we should be rigorous in construction, and customers should use it in the right way. When transporting epoxy floor paint materials to the construction site, it should be noted that if large quantities of special containers or packing boxes are used to prevent the mixing of any kind of fire, and keep the temperature not too high 15-25 C, not mixing with other chemicals and other goods. When arriving at the destination, it is not allowed to cover directly in the open air. It is not allowed to be covered by tarpaulins. Once the packaging is damaged, it is necessary to replace the packaging in time, but it is forbidden to weld on site. Epoxy floor materials, whether in the warehouse of the manufacturer or shipped to the construction site, should be properly preserved. They should not be exposed to the sun, so as to avoid placing them near or where there are fires. Because epoxy material belongs to inflammable and explosive materials, the storage conditions of materials must be strictly observed at the storage and placement points to prevent fire and explosion accidents caused by various problems. 

环氧地坪漆的蓄存条件：

Storage conditions of epoxy floor paint:

1、保持干燥、阴凉、通风，防止烈日暴晒、邻近火源。

1. Keep dry, cool and ventilated to prevent sun exposure and adjacent fire sources.

2、存蓄区域的温度一般应保持在15～25℃，相随湿度50%～75%，定期通风。

2. Temperature in storage area should be maintained at 15-25 C, 50%-75% with humidity, and ventilated regularly.

3、库房的地面一般为水泥或石质地面，地面上应搁上水泥或木质横栅,将桶垫空，以免桶底受潮生锈穿孔，堆放环氧地坪漆桶最好不多于三层。

3. The floor of the warehouse is usually cement or stone. The floor should be laid with cement or wooden crossbars and the barrel should be empty so as to avoid dampness, rust and perforation at the bottom of the barrel. It is better to stack the floor lacquer barrel with no more than three layers.

注意事项：

Matters needing attention:

把环氧地坪漆要有专门的配料房或在室外施工现场， 不能在仓库内配料。 配料房附近不得有火源，并配置一定的消防设备。配料房内不得过多存放易燃易爆物品，并应经常清理， 保持整洁。切勿将易燃环氧地坪漆或稀释剂放置在人员经常走动，操作的地方。

The epoxy floor paint should have a special batching room or be constructed outdoors. It can not be batched in the warehouse. There shall be no fire source near the batching room, and certain fire fighting equipment shall be provided. No excessive storage of inflammable and explosive articles shall be allowed in the batching room, and regular cleaning shall be carried out to keep it clean and tidy. Do not place inflammable floor paint or diluent where people often walk and operate.

修补环氧地坪的几种方法

Several Methods of Repairing Epoxy Floor

环氧地坪是一种装饰和功能都极为良好的一种地面产品，由于使用、保养、施工、使用年限等一些原因会使环氧地坪出现破损的情况，那当环氧地坪损坏后，我们要怎样来进行修补呢？首先先让我们来看下环氧地坪一般会出现哪些问题。然后再来提出具体的修补方案。

Epoxy floor is a kind of floor product with excellent decoration and function. Because of some reasons such as use, maintenance, construction and service life, the epoxy floor will be damaged. When the epoxy floor is damaged, how can we repair it? First, let's look at the general problems of epoxy flooring. Then come to the specific repair program.

1．由于客户对地坪使用知识的缺乏而造成的凹坑、破损、划伤，轨轮碾压的痕迹等。

1. The pits, damages, scratches and traces of wheel rolling caused by customer's lack of knowledge of floor use.

2．基层基础差造成的层间剥离，空鼓，建筑结构膨胀缝的拉伸造成的开裂，及防水不当造成的水臌等。

2. Layer peeling, empty drum caused by poor base, cracking caused by tension of expansion joint of building structure, and water heave caused by improper waterproofing, etc.

3．化学药品腐蚀等造成的损害，主要有发黄，发黑、各种顽渍等。

3. The main damage caused by chemical corrosion is yellowing, blackening and various stubborn stains.

4．紫外线照射造成的粉化、脱落。

4. Pulverization and abscission caused by ultraviolet radiation.

5．施工人员本身或原材料形成的缺陷，如凹窝，粉光颗粒、汗渍、空气微尘污染，飞虫．爬虫。

5. Defects of construction personnel or raw materials, such as pits, pink particles, sweat stains, air dust pollution, flying insects and reptiles.

混凝密封固化剂地坪针对以上的几种无锡环氧地坪问题，提出了几种有效的修补方案。

In view of the above problems of epoxy flooring, several effective repairing schemes are put forward.

1．喷涂修补法

1. Spraying repair method

优点：喷涂法修补具有其他方法不可比拟的优点，修补后痕迹较小、美观度好，节约材料。

Advantages: Spraying repair has incomparable advantages compared with other methods. After repair, the traces are smaller, the aesthetics is better, and the materials are saved.

缺点：施工难度较大，对施工人员的要求较高，需要有专业的喷涂设备。

Disadvantage: The construction is difficult, and the requirement for the construction personnel is high. It needs professional spraying equipment.

2．点补法

2. Point complement method

点补法修补是现阶段常用的一种方法，大部分施工人员修补破损环氧地坪均采用此方法。

Point repair is a commonly used method at this stage. Most of the constructors use this method to repair damaged epoxy floors.

优点：施工过程简单、易于掌握，原材料用量较小。

Advantages: The construction process is simple, easy to master, and the amount of raw materials is small.

缺点：修补痕迹明显、不美观、有高度差。

Disadvantage: Repair marks are obvious, not beautiful, with poor height.

3．整体遮盖法

3. Overall Covering Method

优点：美观漂亮。

Advantages: Beautiful.

缺点：成本较高，仅适用于较小空间及化学药品腐蚀较重区域。

Disadvantage: High cost, only suitable for small space and areas where chemicals are heavily corroded.

施工工序同环氧树脂新地面类似，不赘述。

The construction procedure is similar to that of the new epoxy floor, and it is not necessary to elaborate.